Refinishing the Bath Tub

As I mentioned in the bathroom remodeling post, our choices with the worn-nearly-down-to-metal porcelain enamelled cast iron tub were to (a) bring in a cutting torch and cut it in half to enable two power-lifters to carry it out through the door or (b) tear out the entire exterior wall of the room including removing the weight-bearing framing in order to hoist it out that way.

We chose (c): give the ugly tub a make-over and restore its erstwhile beauty.

I had planned to have a professional come refinish the tub, but no one local does this. So, I bought a two-part spray epoxy kit called "Magic ReNew Tub and Tile Refinishing", and did it myself.

Some years ago, I used spray Appliance Epoxy to paint a built-in oven exterior with good and lasting results. So I figured, as bad as this tub was, I certainly couldn't make it worse by trying.

If we only had one bathroom, we'd have had to arrange to shower at a friend's and brush our teeth in the kitchen for the couple of weeks this project required. As it was, we have two so just kept the door shut on this one.

The hardest part was cleaning and prep. This took a long time (several repetitive hours over the course of a week), but the final result will not work if the preparation is not scrupulous. Any residue of soap or oil hidden in a scratch will prevent the epoxy from adhering and cause it to peel.  I was careful not to stay on my knees too much and did as much work as possible from a crouch or sitting position.

I removed the drain cover and overflow cover before starting. The I put on my goggles, my rubber gloves, and set to work. I scrubbed, cleaned with TSP (per directions on refinishing kit & using all precautions listed on the TSP package itself), sanded, steel wooled.. then scrubbed, cleaned with TSP, sanded, steel wooled... some more for at least three times. I'd work on it after work each evening until I gave out, then start over the next day.

After the final final rinse, I let it dry for several days. That's another essential - absolute dryness.  Then I  masked EVERYTHING.

Seriously, this job can't be done without covering everything from the floor to walls with sheets and paper, as the spray paint will drift and settle and is impossible to remove. I left it all masked until the whole job was finished.

I followed all instructions carefully, especially the safety instructions, and including the interesting chill one/heat one method for mixing the contents of the two cans.

This task requires an experienced hand with canned spray paint. It would be wise to practice by repainting a set of wicker lawn furniture or something until one gets comfortable with the on/off, back/forth motion that covers without drips. I applied the several coats of epoxy over a course of days in the evenings, and closed that bathroom off completely to allow the full length of time to cure undisturbed.

While I will not be volunteering to do this for anyone else, and I still would recommend a professional if you can possibly get one, I am VERY happy with the results for a "homemade" job of it.

Bluebird Bathroom Remodel

This house is over a hundred years old, and when we bought it, we locked the door on the old smallest bathroom until we could get it redone. As it turned out, my eldest, Devin, took the bull by the horns and rebuilt it. What a wonderful thing a son is! :-)

Here's the finished product:

And here's the scary "before":

The old floor had rotted, except for that under the cast iron tub, so he took it down to earth and built a new subfloor for the main part of the room. While the floor was out, he also did some leveling and reinforcing.

Tearing into an old house is always an adventure. (Maybe I'll post pictures nexxt Halloween ;-) )The original wall is solid wood boards, and backs up on a bedroom. Not wanting to lose space in either room by messing with the wall, we made the choices to limit what we did there. Thus, the single high electrical outlet is still the only one; and the medicine cabinet hangs on the wall instead of being recessed.

The room is 3 feet wide by 8 feet long, not counting the tub enclosure/hot water heater closet. Replaced the toilet and added a small pedestal sink to free up as much space as possible, but removing half a ton of bathtub wasn't happening, so I refinished it (more on that later, in my next post).

The new window went into the same hole the old one came out of - again to avoid a cascade of consequences: the solid wood exterior wall, the exterior siding, and more important, the location of structural elements.

We did add a shower, which this bath had never had, and the window placement presented a clallenge there. The window extends into the shower enclosure past the edge of the tub, so there isn't a wall area to attach a curtain rod on that end.  We handled that by using a curved shower rod - worked like a charm!

Paul said "I can't believe you actually had a laundry bag with bluebirds on it!"  It has been in the laundry room for a while but it never really "fit" in there - this is a much nicer spot for it. It pays sometimes to be a packrat.

The pale baby blue and white are comforting in such a small room. The curtains are a pair of crisp cotton pillowcases with a rod pocket sewn into the top. The soft vintage embroidery at the wide hem is touched with blue.

These little sconce shelves are made of metal - iron, I think.




This little guy is from the 1960s heyday of ceramic and chalkware figural wall art. He's made of ceramic and I love his pretty googly eyes!

This glass Blue Bird of Happiness hides in the medicine cabinet, along with an antique Victorian Sunday School card and assorted pretty guest soaps,  ready to promote a smile from a visitor.

The bluebirds were a sort of accident - I didn't have to buy a single one. Who knew there were so many blue bird themed items lurking around my house?

The famed Bluebird of Happiness does live in one's own backyard... and kitchen cupboard... and desk drawer... and linen closet... and laundry room... Hee!

The entire project took Devin several days of hard work over the course of a couple of months  - rushing down here to work on his days off when he wasn't needed at home (he lives four hours away).  The demolition was the most difficult part. What an amazing rennovation once it was complete!

What an amazing son to do this for us. Thank you so much Honey!